Citation

Poosanthanasarn N, Lohachit C, Fungladda W, Sriboorapa S, Pulkate C. Southeast Asian J. Trop. Med. Public Health 2005; 36(2): 512-522.

Affiliation

Division of Environmental Science, Faculty of Science, Ramkhamhaeng University, Ramkhamhaeng Road, Huamark, Bangkapi, Bangkok 10240, Thailand.

Copyright

(Copyright © 2005, SEAMO Regional Tropical Medicine and Public Health Network)

DOI

unavailable

PMID

15916064

Abstract

An ergonomics intervention program (EIP) was conducted with male employees working in the pressing and storage sections of a metal autoparts factory in Samut Prakan Province, Thailand. The objectives of this study were to assess the causes of injuries in the pressing and storage sections of that factory, and to improve working conditions by reducing worker injuries from accidents and low back muscular discomfort, using an EIR The study design used a participatory research approach which was quasi-experimental with pretest-posttest evaluations, with a non-equivalent control group. A total of 172 male participants working in Building A were the target group for assessing causes of injury. A retrospective study of official accident information, and questionnaires for general information, health and muscular discomfort, injury frequency rate (IFR), injury severity rate (ISR), medical expenses, and EIP design. Two groups of employees volunteered for the study on muscular back discomfort. The first group of 35 persons volunteered to participate in the EIP (EIP group), and the second 17 persons from Building B did not (non-EIP group). The EIP was composed of 4 major categories: (1) engineering improvement, (2) change in personal protective equipment, (3) environmental improvement, (4) administrative intervention, training, and health education. Low back muscular discomfort was measured through questionnaires on subjective feelings of muscular discomfort, and by surface electromyography (sEMG). Muscle activities were measured by sEMG of the left and right erector spinae and multifidus muscles, and evaluated by multivariate test for dependent samples (paired observation), and multivariate test for two independent samples. After EIP, IFR decreased 65.46%, ISR decreased 41.02%, and medical expenses decreased 42.79%. The low back muscular loads of the EIP group were significantly reduced, with a 95% confidence level (p < 0.05) while those of the non-EIP group were not. Subjective feelings of muscular discomfort, determined by Wilcoxon Signed Ranks test, showed that after applying the EIP to the EIP group, the mean scores for general bodily discomfort and low back muscular discomfort in the EIP group had significantly reduced, while those of the non-EIP group increased, (p < 0.05).